稷山县 口径100mm化工泵 河北韩辉水泵厂化工泵在工作前，泵体和吸入管必须充满液体，开泵后，叶轮高速旋转，其中的液体随着叶片一起旋转，在离心力的作用下，飞离叶轮向外射出，射出的液体在泵壳扩散室内速度逐渐变慢，压力逐渐增加，然后从泵出口，排出管流出。液体这样不断循环，就可以实现连续输送。化工泵具有性能范围广、效率高、"三化"水平高和维修方便等特点，其效率比F型泵平均提高5%，是机械工业部确定取代F 型耐腐蚀离心泵的节能、更新换代产品。供输送不含固体颗粒具有腐蚀性、粘度类似水的液体。稷山县 口径100mm化工泵 河北韩辉水泵厂 韩辉水水泵以市场为核心，靠质量万里行，在全国各大中型城市设有销售服务公司或分支机构，形成了一个系统性的销售服务网络，完全彻底的免除了用户的一切后顾之忧，使公司的新产品一步步向新市场拓展，公司追求“公平、争X、创新、诚信”的作风，本着“精心制造、尽心服务”的原则，真诚与各界朋友开展广泛的合作，共同创造一个美好的未来。Q-Q13731228538 订货热线：13833222172稷山县 口径100mm化工泵 河北韩辉水泵厂化工泵安装说明1、泵的安装是否合理，对泵的正常运行和使用寿命有很重要的影响，所以安装前必须仔细校正，不得草率，泵的外形及安装尺寸，详见困5和表4。2、必须保证泵在工作时不X过其允许汽蚀余量。泵的吸上高度《或倒灌高度）必须根据泵的汽蚀余量特性，管路阻力损失特性及高温水的吸入液面压力来确定。泵吸上使用情况下，应在吸入管路上装上底阀，并在出口管路上设置壤液螺孔或阀门，以供起动前灌泵之用；泵倒灌使用情况下，应在吸入管路上装上阀门和过滤器，以免杂物进入。3、吸入和吐出管路应该另有支架，不能用泵作支承。4、安装泵的地点，应便于巡回检查和检修。5、安装顺序① 将机组放在埋有地脚螺栓的基础上，在底座和基础之间放置成对的楔垫作找正之用。② 松开联轴器。用水平仪分别放在泵轴或底座上，通过调整禊垫，找正机组的水平后，适当拧紧地脚螺栓，以防走动。③ 用混凝土灌注底座和地脚螺检孔。④ 待混凝土干涸后，应拧紧地脚螺栓，^并重新检查泵轴的?平度。⑤ 在接好管路及确定原动机转动方向以后，接上联轴器，再核对一遍轴的同心度，测量联轴器的外园上下，左右的差异不得X过0.1mm,两联轴器端面间隙，在一周内X大和X小的间咪差不得X过0.3mm.⑥ 在机组实际运行3 — 4小时后作X后检查，如无不良现象，则认为安装合格。型号转速 n流量 Q扬程 H效率 η功率 P必需汽蚀余量（r/min） （m3/h）（L/S）（m） （%） 轴功率电机功率（NPSH）r （KW）（m）IH50-32-125290012.53.4720511.332.2214506.31.755450.190.552IH50-32-125A290011.33.1416.4501.011.5214505.71.584.1430.150.552IH50-32-160290012.53.4732462.373214506.31.758400.340.552IH50-32-160A290011.33.1426.4441.853214505.71.586.637.10.280.552IH50-32-200290012.53.4750394.365.5214506.31.7512.5330.651.12IH50-32-200A290011.33.1441383.244214505.71.5810.3310.520.752IH50-32-250290012.53.4780338.2511214506.31.7520271.272.22IH50-32-250A290011.73.2570326.9711214505.91.6417.5251.251.52IH50-32-250B2900113.0662306.197.52IH65-50-1252900256.9420622.232145012.53.475550.310.552IH65-50-125A290022.76.3116.5611.672.22145011.33.144.1540.230.552IH65-50-1602900256.9432573.825.52145012.53.478510.530.752IH65-50-160A290022.76.3126.5562.9342145011.33.146.649.60.410.552IH65-40-2002900256.9450526.55112145012.53.4712.5460.931.52IH65-40-200A290022.76.3141505.077.52145011.33.1410.3440.721.12IH65-40-2502900256.94804611.84152145012.53.4720391.7532IH65-40-250A290023.46.574.84510.6152145011.73.2517.537.91.472.22IH65-40-250B2900226.1161.8448.42112IH65-40-3152900256.941253921.8302145012.53.4732333.35.52IH65-40-315A290023.46.5109.53818.36302145011.73.2528332.7142IH65-40-315B2900226.1196.53715.63222IH80-65-12529005013.8920693.955.531450256.945640.530.752.5IH80-65-125A290045.312.5816.5673.0443145022.76.314.1620.410.552.5IH80-65-16029005013.8932676.51112.31450256.948620.881.52.3IH80-65-160A290045.312.5826.4655.027.52.3145022.76.316.6600.681.12.3IH80-50-20029005013.89506310.81152.51450256.9412.5571.492.22IH80-50-200A290045.312.5841618.29112.5145022.76.3110.356.11.142.22IH80-50-25029005013.89805320.57302.51450256.9420502.725.52IH80-50-250A290045.312.5865.75215.61222.5145022.76.3116.4492.0732IH80-50-31529005013.891255034.1452.51450256.9432484.547.52.5IH80-50-315A290045.312.58102.64826.4372.5145022.76.3125.7463.465.52.5IH100-80-125290010027.7820737.47114.214505013.895690.991.53.4IH100-80-125A290091.825.516.8715.927.54.2145045.912.754.2670.781.13.4IH100-80-160290010027.78327311.9154.314505013.898681.582.23.4IH100-80-160A29009125.2826.5719.25154.3145045.512.646.6671.221.53.4IH100-65-200290010027.78507218.92223.914505013.8912.5682.532.5IH100-65-200A29009125.2841.57014.718.53.9145045.512.6410.3661.9332.5IH100-65-250290010027.78806832.06373.614505013.8920634.335.52.5IH100-65-250A290093.525.97706527.44373.6145045.512.6417.4613.535.52.5IH100-65-250B290087.824.3961.76423.1303.6IH100-65-315290010027.781256254.94753.214505013.8932587.52112IH100-65-315A290093.525.971096145.53753.2145046.512.9228566.33112IH100-65-315B29008824.44976038.77553.2IH125-100-200290020055.56507735.39455145010027.7812.5734.667.52.9IH125-100-200A290018250.5641.47527.3837514509125.2810.3713.65.52.9IH125-100-250290020055.56807558.13754.5145010027.7820727.56112.3IH125-100-250A2900186.551.8169.57348.35754.514509325.8317.4706.29112.3IH125-100-250B2900175.548.7561.57141.42554.5IH125-100-315290020055.61257294.621104.5145010027.8326513.42222.5IH125-100-315A2900186.551.81108.77177.81904.514509325.8327.26410.77152.5IH125-10-400145010027.78505524.77302.5IH125-100-400A14509325.8343.25420.27302.5IH150-125-250145020055.56207714.1618.52.8IH150-125-250A145018250.5616.57510.91152.8IH150-125-315145020055.6327523.25302.8IH150-125-315A145018250.5625.57317.32222.8IH150-125-315B145016545.83227213.7418.52.8IH150-125-400145020055.56507038.93552.5IH150-125-400A145018250.56416829.94372.5IH150-125-400B145016545.83346722.82302.5IH200-150-2501450400111.11207927.59372.8IH200-150-250A1450363100.8316.57920.66302.8IH200-150-3151450400111.11327944.15553.5IH200-150-315A1450363100.8425.57732.76453.5IH200-150-315B145032991.3921.67625.48373.5IH200-150-4001450400111.11507869.87903.5IH200-150-400A1450363100.83417653.36753.5IH200-150-400B145032991.3933.87540.4553.5
