河北会泉泵业有限公司
五金通钻石会员 第13年
已通过企业工商认证
公司服务热线
13582138818
泗水「渣浆泵工作原理」欢迎前来选购?
The higher the water level, the lower the rotational speed; the lower the water level, the higher the rotational speed. At the same time, the water level signal is transmitted to the control cabinet, so that the operator can understand the level status in a timely manner. This control keeps the circulation in the slurry pool basically unchanged. In order to ensure the efficient operation of the liquid slurry pump, the gap between the impeller and the front guard plate must be adjusted regularly so that it remains between (0.75-1mm). Pump in operation in addition to monitoring the flow, divssure, but also to monitor the motor do not exceed the rated current of the motor. At any time oil seals, bearings, such as whether there is a guide phenomenon, whether the pump occurred emptying or overflow pool, etc., and at any time to deal with. The pump body (cannot) bear the divssure from the outlet piping system, the warehouse spare pump should rotate (1/4) circle every week, so that the shaft can withstand the load and external vibration evenly, belt CR drive for the pump from the inlet to see the motor on the pump (right) side. The slurry pump mainly aims at conveying flow rate. Therefore, in the operation of the monitoring system as far as possible to install the flow meter (meter), at any time to monitor whether the traffic meets the requirements;
一、ZJ渣浆泵概述
ZJ渣浆泵的形式分为两大类，一类是ZJ渣浆泵，为轴向单极单吸离心式渣浆泵；另一类是ZJL渣浆泵，为立式轴向单X单吸离心式渣浆泵。渣浆泵以其X的水力设计、结构设计达到了节能的显著效果，又以渣浆泵材质X良、硬度高、耐磨性好、运行平稳、加工工艺可靠等特点，深受用户X。渣浆泵技术可广泛应用于电力、冶金，煤炭、石油、化工、采矿、工业锅炉、河道疏通等X域。wjhuiquan3.21
二、ZJ渣浆泵的用途和适用范围
渣浆泵系列在水力设计、结构设计以及所用耐磨材料上，综合应用了同类产品的X点并加以创新，具有节能、振动小、噪声低、运行可靠、使用寿命长、方便等特点，渣浆泵的综合性能居国内水平，大部分泵的效率指标居X水平。可广泛用于电力、冶金、煤炭、建材等行业输送含有固体颗粒的浆体。如火电厂水力除灰、冶金选矿厂矿浆输送、洗煤厂煤浆及重介输送等。其允许输送的浆体重量浓度Cw为：灰（渣）浆和煤浆45%；矿浆和重介60%。
泗水「渣浆泵工作原理」欢迎前来选购?
主要体现在“大牛拉小犁，小牛拉大犁”两个方面，尤其是种现象特别多，配套功率选得大，致使电能浪费非常大。而后者配套功率选得小，即“小牛拉大犁”，会造成渣浆泵的供浆量不足。电机或带不动泵，都不能保证设备、经济的运行，必须要电机与渣浆泵功率合理配套，才是解决的办法。如果条件许可，在安装渣浆泵时，尽量弯头用量，或取消“三阀”，管路直、短，不要将管设置成“高射炮”式，可采取下卧安装、倾斜安装等，损耗。管路直径大小对损失扬程影响很大，采取水管直径略大渣浆泵口径一个等X，可渣浆泵的输送效率。对矿业公司而言，渣浆泵的前护板一般来说根据工况条件使用寿命应在2000h左右，但是。
三、从近几年来泵站的运行情况看，ZJ渣浆泵有以下X点：
1、ZJ渣浆泵效率高，节电效果明显。泵站运行电流平均下降30A，效率指标高出国内同类及国外相应泵2-10个百分点。
2、ZJ渣浆泵过流部件寿命长。一般能连续运行3000-4000小时，其寿命是12P-7型泵的5倍以上。
3、ZJ渣浆泵运行平稳、振动小、噪音低、了泵站的工作。
4、ZJ渣浆泵轴承箱结构合理，密封好，运行温度低。轴承使用寿命是12P-7型泵使用326轴承的9倍以上。
5、渣浆泵过流部件设计合理，拆卸方便。ZL型渣浆泵是节能降耗，效益的好产品，建议广泛推广。
选定了一个由铁液直浇道再经横浇道后由侧冒口引入铸件的浇注，侧冒口压力角≥10°，高度取300mm。浇注温度控制在1370～1390℃，浇注重量约为250kg，浇注后48h后打箱。铸件清理去冒口及披缝后进行淬火+回火。断裂原因分析通常铸件断裂原因主要有铁液化学成分X标和铸造缺陷。取断裂护板试样进行化学成分检验，经查化学成分合格，wP≤0.06﹪、wS≤0.06﹪，wSi≤1.0﹪，均在合格范围内，排除了成分原因。那么初步判断铸造缺陷是造成前护板断裂的主要原因。铸件内部气缩孔严重影响铸件内在，从而造成使用寿命，对此我们深入剖析原因。（1）前护板口底部属热节部位，侧冒口距口底部较远。
ZJ渣浆泵简介
泵体泵盖及过流部件：该系列泵为、垂直中形式、双泵壳结构渣浆泵。泵体和泵盖带有可更换的金属内衬，内衬材质为高铬耐磨合金材料，内衬可一直用到磨穿为止，周期，运行成本。泵的出口方向可按8个角度安装。
轴承组件：泵的轴承组件采用圆筒式结构，便于叶轮与前护板的间隙，时可整体拆出。轴承采用油脂。
轴封（密封）：泵的轴封型式有填料密封、付叶轮密封、机械密封。
泗水「渣浆泵工作原理」欢迎前来选购?
The higher the water level, the lower the rotational speed; the lower the water level, the higher the rotational speed. At the same time, the water level signal is transmitted to the control cabinet, so that the operator can understand the level status in a timely manner. This control keeps the circulation in the slurry pool basically unchanged. In order to ensure the efficient operation of the liquid slurry pump, the gap between the impeller and the front guard plate must be adjusted regularly so that it remains between (0.75-1mm). Pump in operation in addition to monitoring the flow, divssure, but also to monitor the motor do not exceed the rated current of the motor. At any time oil seals, bearings, such as whether there is a guide phenomenon, whether the pump occurred emptying or overflow pool, etc., and at any time to deal with. The pump body (cannot) bear the divssure from the outlet piping system, the warehouse spare pump should rotate (1/4) circle every week, so that the shaft can withstand the load and external vibration evenly, belt CR drive for the pump from the inlet to see the motor on the pump (right) side. The slurry pump mainly aims at conveying flow rate. Therefore, in the operation of the monitoring system as far as possible to install the flow meter (meter), at any time to monitor whether the traffic meets the requirements;
ZJ渣浆特点和用途：
随着杂质泵技术的发展和完善，我公司结合用户反馈，利用现代流体力学的理论，现代机械理论，电脑设计技术;我公司推出了ZJ系列渣浆泵，该系列渣浆泵具有型号全、性能，覆盖工况广、选型方便等特点
回报社会，奉献客户。X制造双吸泵多X泵渣浆泵，污水泵和清水泵的厂商，公司主要致力于工业水泵的研发，生产与销售。公司技术力量雄厚，水平X。具有一批高素质，高水平，丰富的技术精英。电力，煤炭，石油等行业提供十余种系列五百余种规格的配套用泵公司将“诚信卓越”作为理念，不断强化内部。公司广泛吸引国内创新技术严格执行ISO9001体系。为冶金创造性的出一系列具有国内X水平的水泵产品。HH，ZGM，ZGP(P)型系列渣浆泵，SP，SPR型液下泵，HW混流泵，泵等产品，目前产品已畅销二十余个省市地区。SH双吸泵，LXL.ZBJ.ZC.ZE型纸浆泵AFB型耐腐离心泵，AY型油泵。
